Product ID:01564 ALMAG OIL
MSDS Date:08/24/1989
FSC:9150
NIIN:01-048-9554
MSDS Number: BGHXZ

Emergency Phone: 914-831-3400 EXT 204

Info Phone: 914-831-3400 EXT 204

Preparer: M.J.VON ALLMEN

Cage: 7B131

Telephone: 914-831-3400

Cage: 7B131

MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED LIGHT

CAS: 64742-53-6

RTECS: PY8036000

Fraction By Weight: 100%

ACGIH TLV: 5 MG/M3 (OIL MIST)

LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HIGH VAPOR LEVELS MAY CAUSE EYE
IRRITATION. THE LIQUID IS SLIGHTLY IRRITATING TO THE SKIN.
PROLONGED OR REPEATED CONTACT CAN RESULT IN DEFATTING AND DRYING
WHICH MAY RESULT IN SKIN IRRITATION AND DERM ATITIS. INHALATION OF
VAPORS MAY BE IRRITATING TO NOSE & LUNGS. MAY CAUSE CNS DEPRESSION.
INGESTION MAY CAUSE VOMITING
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE, SKIN & RESPIRATORY TRACT IRRITATION.
CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION MAY BE EVIDENCED BY
GIDDINESS, HEADACHE, DIZZINESS AND NAUSEA. ASPIRATION OF VOMITUS
INTO THE LUNGS MAY CAUSE COUGHING , LABORED BREATHING, CYANOSIS AND
IN SEVERE CASES, DEATH.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL
ATTENTION. INHALA TION: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH
RESUSCITATION IF NOT BREATHING. GET MEDICAL ATTENTION. INGESTION:
DO NOT INDUCE VOMITING. KEEP HEAD BELOW HIPS IF VOMITING OCCURS.
GET MEDICAL ATTENTION.

Flash Point Method:COC
Flash Point:265F,129C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:CONTAIN SPILL IF POSSIBLE. WIPE UP OR ABSORB
ON SUITABLE MATERIAL, SHOVEL INTO CLOSED CONTAINERS.
Neutralizing Agent:NOT APPLICABLE.

Handling and Storage Precautions:KEEP LIQUID/VAPOR AWAY FROM HEAT,
SPARKS & FLAME. KEEP CONTAINERS CLOSED WHEN NOT IN USE. USE WITH
ADEQUATE VENTILATION. IGNITED VAPORS MAY EXPLODE.
Other Precautions:"EMPTY" CONTAINERS CAN CONTAIN EXPLOSIVE VAPORS. DO
NOT CUT, DRILL, GRIND, WELD OR PERFORM SIMILAR OPERATIONS ON OR
NEAR CONTAINERS. STATIC ELECTRICITY MAY ACCUMULATE AND CREATE A
FIRE HAZARD. GROUND CONTAINERS, FIXED & TRANSFER EQUIPMENT.

Respiratory Protection:AVOID PROLONGED OR REPEATED BREATHING OF VAPORS.
IF EXPOSURE EXCEEDS OCCUPATIONAL EXPOSURE LIMITS, USE A NIOSH/MSHA
APPROVED RESPIRATOR. EITHER AN AIR-SUPPLIED OR AIR-PURIFYING
RESPIRATOR WITH ORGANIC VAPOR CARTRIDGES IS RECOMMENDED.
Ventilation:USE EXPLOSION-PROOF LOCAL AND/OR MECHANICAL VENTILATION.
AVOID OPEN ELECTRICAL SOURCES NEAR PRODUCT VAPOR AREAS.
Protective Gloves:NEOPRENE, NITRILE, OR POLYVINYL ALCOHOL
Eye Protection:USE CHEMICAL SAFETY GOGGLES & FACESHIELD
Other Protective Equipment:INDUSTRIAL WORK CLOTHING TO MINIMIZE
CONTACT. RUBBER APRON AD BOOTS AS REQUIRED. EYE BATH AND SAFETY
SHOWER RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USING PRODUCT AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNDER EPA-CWA, THIS PRODUCT IS CLASSIFIED AS AN OIL UNDER SECTION 311.
SPILLS INTO OR LEADING TO SURFACE WATERS THAT CAUSE A SHEEN MUST BE
REPORTED TO THE NATIONAL RESPONSE CENTER, 800-424-8802. UNDER
EPA-CERCLA, RELEASES TO AIR, LAND OR WATER MAY BE REPORTABLE TO THE
NATIONAL RESPONSE CENTER, 800-424-8802.

HCC:V6
Boiling Pt:B.P. Text:424F,218C
Viscosity:9.49CST@40C
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT PALE LIQUID
Percent Volatiles by Volume:UNKNON

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER HYDROCARBON COMPOUNDS DURING COMBUSTION.

Waste Disposal Methods:USER IS RESPONSIBLE FOR DETERMINING IF WASTE IS
CONSIDERED HAZARDOUS UNDER RCRA. MATERIAL IS NOT A HAZARDOUS WASTE
IN ITS UNUSED FORM. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE AND FED ERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.